US aviation shutdown blamed on L3 Harris installed router
WASHINGTON, Nov 14 -
asserted
shutdown → blame → router
A massive, nearly five-hour shutdown of the US aviation system that has disrupted more than 20,000 flights since Friday may have been the fault of a single router installed by government contractor L3Harris, government officials said Saturday.
uncertain
officials → disrupt → L3Harris
The incident is the latest painful example of the aging US air traffic control telecom system and the struggles to replace systems while keeping the old communications working.
asserted
incident → age → communications
The FAA's aging telecom systems in recent years have failed after errant fiber cuts, accidental deletion of files and a strong chemical smell caused by a melted component.
asserted
systems → age → component
The system will fail again until it is properly upgraded, officials said.
asserted
officials → fail → ?
"This was an FAA system that didn't meet the moment," Transportation Secretary Sean Duffy said Saturday.
asserted
Duffy → meet → moment
Duffy said on Friday L3Harris was conducting routine maintenance to switch telecommunication lines from old copper wire to fiber at at least one remote location.
asserted
L3Harris → say → location
Officials told Reuters there may have been problems with routers installed in both Arkansas and Texas.
uncertain
Officials → tell → Arkansas
"We're working to determine whether we had incompetence, meaning was it user error or installer error from L3Harris, or did they install a faulty router?
asserted
they → work → router
We haven't determined what the fault was," Duffy said.
asserted
Duffy → determine → ?
L3Harris said it took the issue seriously and was "supporting the FAA in its investigation to understand the conditions that led to the Nov. 13 ground stop of our nation’s air travel.
asserted
that → say → travel
"
L3 noted it has completed more than 70% of the planned airspace communications conversion from legacy copper wires to a fiber-optic system.
asserted
it → note → system
The FAA spends $1 billion annually to maintain its old copper wire system and is racing to replace it with more modern fiber-based communications.
"We need L3Harris or whoever provided that router to us to do a better job," Duffy said, noting that "virtually every single institution in America has gone from copper to fiber, from analog to digital."
The issue began overloading communications at 17 of the FAA's 22 en route centers across the country, which prompted the FAA to issue a nationwide ground stop because it could not identify a root cause.
uncertain
it → spend → cause
Duffy said the new routers started flooding other routers with over 1,000 connection attempts every four to five seconds, which sparked communications issues with planes and radar at FAA facilities.
asserted
which → say → facilities
Bedford said the FAA had to take the action when it lost "the ability for those routers to communicate data."
asserted
routers → say → data
The FAA is still trying to understand the root cause of what went wrong.
asserted
what → try → cause
The FAA said communications did not go down but led to instability in data at the centers.
asserted
communications → say → centers
It did not lead to centers going dark.
asserted
centers → lead → ?
The routers being replaced are about 25 years old, Duffy said, and were supposed to be replaced in 2006.
asserted
Duffy → replace → 2006
Small mishaps leading to catastrophic consequences are not new to the US air traffic control network.
asserted
mishaps → lead → network
A 2023 FAA nationwide ground stop that lasted 90 minutes and disrupted 11,000 flights was caused by a government contractor unintentionally deleting files.
asserted
contractor → last → files
That led to the first nationwide ground stop since the hijacked airplane attacks on September 11, 2001.
asserted
That → lead → September
Friday's outage hit as a surge in travelers began weekend travel.
asserted
surge → hit → travel
Noting the poor timing, Duffy said they would reevaluate when work is done at smaller facilities to prevent future disruptions.
asserted
work → note → disruptions
The FAA got $12.5 billion to upgrade its badly aging air traffic control and telecom system from Congress and Duffy has asked for $50 billion more for air traffic control and airports.
asserted
Duffy → get → control
The FAA only last week said it would replace by the end of 2028 outdated floppy disks used for weather and other critical information at more than 400 air traffic control facilities.
asserted
it → say → facilities
The FAA relies on a telecoms system it is racing to replace as well as decades-old Compaq computers and replacement parts bought on eBay.
asserted
it → rely → eBay
In September, thousands of flights across the densely populated Northeast were delayed or canceled due to the dual failures of a circuit at a Philadelphia air traffic facility and the accidental severing of a fiber-optic cable in New Jersey by a construction crew.
asserted
thousands → delay → crew
The FAA has also been working for years to end a long-ridiculed, decades-old practice of air traffic controllers using paper flight strips to keep track of aircraft.
asserted
controllers → work → aircraft
But adopting the change, which started in 2022, at 49 major airports will take until at least 2028.
asserted
which → adopt → 2028
The Aporia
